Indian Journal of Occupational and Environmental Medicine   Official publication of Indian Association of  0ccupational  Health  
 Print this page Email this page   Small font sizeDefault font sizeIncrease font size
 Users Online:271

  IAOH | Subscription | e-Alerts | Feedback | Login 

Home About us Current Issue Archives Search Instructions
  Search
 
  
 
    Similar in PUBMED
     Search Pubmed for
     Search in Google Scholar for
   Related articles
    Article in PDF (599 KB)
    Citation Manager
    Access Statistics
    Reader Comments
    Email Alert *
    Add to My List *
* Registration required (free)  


   Abstract
  Introduction
  Case History
  Discussion
   References
   Article Figures

 Article Access Statistics
    Viewed395    
    Printed2    
    Emailed0    
    PDF Downloaded22    
    Comments [Add]    

Recommend this journal

 


 
  Table of Contents 
CASE REPORT
Year : 2016  |  Volume : 20  |  Issue : 2  |  Page : 118-120
 

Occupational bronchiolitis induced by cotton dust exposure in a nonsmoker


Department of Pulmonary Medicine, Vallabhbhai Patel Chest Institute, University of Delhi, New Delhi, India

Date of Web Publication4-Jan-2017

Correspondence Address:
Sunil K Chhabra
Department of Pulmonary Medicine, Vallabhbhai Patel Chest Institute, University of Delhi, New Delhi - 110 007
India
Login to access the Email id

Source of Support: None, Conflict of Interest: None


DOI: 10.4103/0019-5278.197550

Rights and Permissions

 

  Abstract 

The most well-known disease caused by cotton dust is byssinosis though it is also associated with chronic obstructive airways disease, and very rarely, interstitial lung disease. Obliterative bronchiolitis has never been reported in this setting. We report a 63-year-old, nonsmoker male, who presented with complaints of cough and exertional dyspnoea for 10 years. He had worked in textile industry for 35 years and symptoms had persisted even after quitting. Examination revealed prolonged expiration with expiratory wheeze, and pulmonary function tests revealed severe airflow limitation with air trapping and impaired diffusion capacity. Arterial blood gas analysis showed type I respiratory failure. A high resolution computed tomogram of the chest showed bilateral centrilobular nodules with tree-in-bud pattern and areas of air trapping. A diagnosis of obliterative bronchiolitis induced by cotton dust exposure was established on the basis of the occupational history and the characteristic radiological signs.


Keywords: Cotton dust, high resolution computed tomogram, obliterative bronchiolitis, occupational bronchiolitis, pulmonary function tests


How to cite this article:
Mittal R, Gupta P, Chhabra SK. Occupational bronchiolitis induced by cotton dust exposure in a nonsmoker. Indian J Occup Environ Med 2016;20:118-20

How to cite this URL:
Mittal R, Gupta P, Chhabra SK. Occupational bronchiolitis induced by cotton dust exposure in a nonsmoker. Indian J Occup Environ Med [serial online] 2016 [cited 2017 May 25];20:118-20. Available from: http://www.ijoem.com/text.asp?2016/20/2/118/197550



  Introduction Top


Employment in cotton processing industry is associated with exposure to broken cotton fibers, bracts, and pericarps as well as to bacteria and fungi that may grow on cotton products. The classical occupational lung disease associated with cotton industry is byssinosis, an acute and reversible response to cotton dust characterized by chest tightness on working days and remitting on off-days only to relapse upon re-exposure. [1] Other chronic effects of cotton industry-associated exposure have received much less attention include obstructive airway diseases, [2] interstitial lung disease, and hypersensitivity pneumonitis. [3],[4]

Bronchiolar disorders are a group of diseases of diverse etiology predominantly involving the membranous and the more distal airways. [5] These diseases are not known to be associated with cotton exposure. We diagnosed a case of obliterative bronchiolitis in a nonsmoker male with 4 decades of employment in cotton processing industry. The case is reported in view of the absence of any previous report of such an association.


  Case History Top


A 63-year-old nonsmoker male presented with 10-year complaints of recurrent dry cough and progressive exertional dyspnoea, limiting his activities severely at present. There was no history of hemoptysis, joint pains, fever, chest pain, or any constitutional symptoms. Past and family histories were unremarkable. He had worked in the textile industry processing raw cotton for 35 years, but had quit following the development of symptoms. The intensity of symptoms at work and on off-days was similar. The symptoms had continued to worsen progressively even after leaving the job. Examination revealed prolonged expiration and expiratory wheeze.

Chest radiography showed bilateral hyperinflated lung fields with low flat diaphragms [Figure 1]. The electrocardiogram showed a north-west axis with a right bundle branch block and poor progression of R waves. Lung function study revealed severe airflow limitation with hyperinflation and air trapping and impaired diffusion capacity. The forced vital capacity (FVC) was 1.64 L (68% of predicted), forced expiratory volume in 1 second (FEV 1 ) was 0.41 L (21% of predicted) with an FEV 1 /FVC ratio of 25%. Post-bronchodilator, the FVC showed a 300 ml and 18% increase over the baseline and FEV1 increased by 110 ml and 26%. Lung volumes measurement by closed-circuit multiple-breath Helium dilution showed a residual volume (RV) of 2.74 L (148% of predicted), functional residual capacity (FRC) of 3.68 L (140% of predicted), and a total lung capacity (TLC) of 4.49 L (105% of predicted). The RV/TLC ratio was 61% (179% of predicted). Single breath diffusion capacity for carbon monoxide (DLCO) was 14.3 ml/min/mmHg (69% of predicted). Pulse oximetry showed a saturation of 90% on room air at rest. Arterial blood gas analysis showed moderate hypoxaemia and mild metabolic alkalosis (pH 7.45, PCO 2 45.9 mmHg, PO 2 58.6 mmHg and HCO 3 − 33.6 meq/L). A six-minute walk test resulted in further desaturation to 84% within 1 minute. Serum rheumatoid factor, antinuclear antibodies and cross-reactive protein (CRP) were in the normal range.
Figure 1: Chest radiograph (PA view) showing bilateral hyperinflated lung fields with low flat diaphragms

Click here to view


A high resolution computed tomogram (HRCT) of the chest showed bilateral centrilobular nodules with tree-in-bud pattern and areas of air trapping [Figure 2]. A diagnosis of cotton exposure-associated obliterative bronchiolitis was established based on clinical features and occupational history, a highly characteristic HRCT picture and supportive evidence on lung function testing. The patient was advised treatment with inhaled corticosteroids, inhaled long acting bronchodilators (formoterol and tiotropium) and pulmonary rehabilitation.
Figure 2: High resolution computed tomogram (HRCT) of the chest showing bilateral centrilobular nodules with tree-in-bud pattern (arrow) and areas of air trapping (arrow)

Click here to view



  Discussion Top


The Occupational Safety and Health Administration (OSHA) of the United States of America has designated cotton dust exposure as one of the five occupational health hazards. The most well-known disease caused by cotton dust is byssinosis though chronic obstructive pulmonary disease (COPD) is also known to occur with occasional reports of diffuse pulmonary fibrosis. [3],[4] Several studies have shown that cotton workers have a significant decline in FEV1 annually. [6] In addition, exposed workers may also develop changes in airways reactivity. Changes in both reactivity and airways caliber have led to the suggestion that small airways maybe affected by cotton dust exposure. [7] An inflammatory response in the small airways may be due, in part, to the contamination by gram-negative bacterial products. The specific effect of exposure may depend on the site of deposition in the tracheobronchial tree, duration of exposure, action of specific components of the dust, as well as the presence of other confounding causative agents such as smoking. [8]

Obliterative bronchiolitis is an uncommon and severe form of obstructive airways disease involving the small airways. Its diverse etiologies include smoking, collagen vascular diseases, inhalational injury, certain drugs, and organ transplantation. Known inhalational exposures include chlorine, ammonia, oxides of nitrogen, sulfur dioxide, and other gases besides diacetyl, a chemical used to provide butter flavor in many foods. [9] However, it has rarely been reported in association with organic dusts but never in relation to cotton-processing industry. [10] While symptoms, plain radiological features, and the spirometric abnormality resemble those seen in COPD, it is the radiological signs that differentiate the two.

Direct signs of bronchiolitis obliterans include ill-defined centrilobular nodules and tree-in-bud opacities whereas indirect signs of small airways disease include a mosaic pattern of attenuation (on inspiratory CT scan) and air trapping (on expiratory CT scan). [5] This picture is virtually diagnostic and obviates the need for a biopsy. A fibreoptic transbronchial biopsy was not done in the present case because of resting hypoxemia and also because the yield in small airways disease is usually poor and would not have justified the risk. A histological confirmation by open or a video-assisted thoracoscopic lung biopsy was not considered necessary because the HRCT picture was diagnostic. There was no evidence of other causes mentioned above. Absence of a history of smoking ruled out respiratory bronchiolitis. In view of long occupational exposure to cotton dust, symptoms, characteristic picture on HRCT scan, exclusion of other causes and supportive evidence on lung function testing, a diagnosis of obliterative bronchiolitis-induced by cotton dust exposure was made.

The present case adds obliterative bronchiolitis to the spectrum of respiratory diseases known to occur with cotton dust exposure. An HRCT of the chest is recommended in patients working in cotton-processing industry and reporting dyspnea.

Financial support and sponsorship

Nil.

Conflicts of interest

There are no conflicts of interest.

 
  References Top

1.
Schilling RS. Byssinosis in cotton and other textile workers. Lancet 1956;271:261-5.  Back to cited text no. 1
    
2.
Glindmeyer HW, Lefante JJ, Jones RN, Rando RJ, Weill H. Cotton dust and across-shift change in FEV1 as predictors of annual change in FEV1. Am J Respir Crit Care Med 1994;149:584-90.  Back to cited text no. 2
    
3.
Kobayashi H, Kanoh S, Motoyoshi K, Aida S. Diffuse lung disease caused by cotton fibre inhalation but distinct from byssinosis. Thorax 2004;59:1095-7.  Back to cited text no. 3
    
4.
Gothi D, Joshi JM. An unusual interstitial lung disease. Ann Thorac Med 2012;7:162-4.  Back to cited text no. 4
  Medknow Journal  
5.
Devakonda A, Raoof S, Sung A, Travis WD, Naidich D. Bronchiolar disorders: A clinical-radiological diagnostic algorithm. Chest 2010;137:938-51.  Back to cited text no. 5
    
6.
Glindmeyer HW, Lefante JJ, Jones RN, Rando RJ, Abdel Kader HM, Weill H. Exposure-related declines in the lung function of cotton textile workers. Relationship to current workplace standards. Am Rev Respir Dis 1991;144:675-83.  Back to cited text no. 6
    
7.
Fishwick D, Fletcher AM, Pickering CA, Niven RM, Faragher EB. Lung function, bronchial reactivity, atopic status and dust exposure in Lancashire cotton mill operatives. Am Rev Respir Dis 1992;145:1103-8.  Back to cited text no. 7
    
8.
Khan AJ, Nanchal R. Cotton dust lung diseases. Curr Opin Pulm Med 2007;13:137-41.  Back to cited text no. 8
    
9.
Barker AF, Bergeron A, Rom WN, Hertz MI. Obliterative Bronchiolitis. N Engl J Med 2014;370:1820-8.  Back to cited text no. 9
    
10.
Kreiss K. Occupational causes of constrictive bronchiolitis. Curr Opin Allergy Clin Immunol 2013;13:167-72.  Back to cited text no. 10
    


    Figures

  [Figure 1], [Figure 2]



 

Top
Print this article  Email this article